airbag light (Full Version)

Volkswagen Forum >> VW MODELS >> Volkswagen Beetle

airbag light

  

larrh7 -> airbag light (1/10/2008 3:16:07 PM)

I have a 2001 New Beetle. The airbag light is now on all the time. A friend has a Beetle and the same thing happened. Took theres to a dealer and had it fixed for $500 and now theirs is back on. Is anyone else having the same problem? I've talked to several people in my small town who have and would assume this is a large problem. Please let me know. Thanks!!

  
toledotom -> RE: airbag light (1/11/2008 6:43:55 AM)

I have a 2001 New Beetle also and I do alot of work on it. The code you are getting is an Airbag light! I have the same problem and found  raising the passenger seat forward to get in the back, the wires get stretched under the seat for the plug which inturns plugs into the wire harness under the seat. I find using the lever to raise the seat UP, then reach under the seat using a flashlight look at the plugs under there. There should be at least 2,or maybe 3, One is for the ABS the other for Heated seats. I found the one for my heated seats got pulled out first! One might be completely unplugged from its mate or just pushing the wire hooked into the plug back in will work! You need a VAS Code reader to plug in and reset the codes. A mechanic friend using his VAS PC reader could actual tell which seat and where code is coming from. My reader will tell you the code but does not get as explicit. It will also rest the trouble light for Engine, ABS, Airbags and Automatic Transmission. I purchased an inexpensive code reader to read the car trouble lights. It is a Geniscan VW/AUDI Code Reader about $45 on-line. Works great! Comes with both VAG & SAE Trouble Codes and reader just plugs into socket located under dash infront of your left knee. My inlet plug is a purple color and easy to see if you look just left center under your steering collum under dash. If you still have problems? E-mail me @ toledotom@aol.com and I can froward you some pictures that might help you find it. Almost all the beetles have this problem, the harness was made about 3" to short and gets pulled forward or out completely when the seats are brought forward to gain access to the back. It might be your Driver's seat too! But most of the problems according to my Mechanic are from the Passenger side!

Smokin Dog -> RE: airbag light (1/11/2008 4:43:24 PM)

     Can't tell you this is the problem. However all the vehicles i've ever worked on, about the air bag light thing.
Vehicles have what is known as a clock spring under the
steering wheel, you have to pull the steering wheel to get
to it. VW may call it something else. That clock spring allows the steering wheel to be able to move, and it feeds
info to the steering wheel air bag. it's nothing but a wire
connection that moves without breaking. After a lot of
driving the spring gets a lot of action and will finally break
so the info is then blocked and the air bag light goes on.
  If you decide to tackel it, disconnect the battery first thing, you could set off the air bag if you don't. The clock
spring can be removed and tested with a volt ohm meter
to see if it has a reading or not. no reading bad...reading of
any kind good. The spring isn't cheep, and the repair isn't
easy. You also have to be sure you have everything correct
or the air bag can go off when you reconnect the battery.

gstramiello -> RE: airbag light (2/19/2008 11:34:14 AM)

I have a 98 Beetle and my airbag light has been on for a few months, and now I'm approaching the need for inspection. So, I had it looked at and was told by a dealer that it will cost close to $1,000!!! They said it's a module and wiring harness!

MY car has 112,000 miles on it and it's not worth spending this much money! I'm very upset.

bagel -> RE: airbag light (2/20/2008 11:09:02 AM)

I had one in my 2000 Jetta.  Turns out when the airbag isn't used, the igniters can go bad.  There's also some mechanism that's electrical that will go bad in the steering wheel( I think) or in the circuit somewhere.

unh95 -> RE: airbag light (3/2/2008 1:24:40 PM)

Thank you for all the information below.  I have a 2000 Beetle and checked the wire under the driver and passenger seat to find the driver side yellow wire was completed severed. 

Sanguinius -> RE: airbag light (3/5/2008 6:22:20 PM)

Glad to hear that it was as simple as that.  You lucked out then.

  

Page: [1]

Return to Volkswagen Forum home page or view the Full Version of this page.