Ac issues on a 99 beetle

Volkswagen Forum VW Classifieds Photo Gallery Search Contact VWF
News Forum FAQ Sponsors Calendars Member List VW Recalls TSBs Timeslips Register Login

Ac issues on a 99 beetle

Printable Version

Volkswagen Forum >> VW MODELS >> Volkswagen Beetle >> Ac issues on a 99 beetle

Page: [1]

Message

<< Older Topic Newer Topic >>

Ac issues on a 99 beetle - 5/7/2008 1:43:53 PM

DonM77

Posts: 4
Joined: 4/26/2008
Status: offline

Ok, my wifes beetle has not had a working AC since early last year. She wasn't worried about it so I let it go untill now.

I checked to see if the compressor kicked on and it did not. However I remember reading someplace that if the system is completly emtpy of freon it was designed not to come on? I also checked the fuses ontop of the batt, all of which looked fine.

My bro had a spare can of AC booster laying around and he brought it up this afternoon. I followed the directions on the can and none of the freon seemed to exit the can. However when I checked the dash vents, the temp seemed to get cool and then warm again, but never cold!

Is there anything else I should check?

thanks

Post #: 1

RE: Ac issues on a 99 beetle - 5/7/2008 2:36:14 PM

bagel

Posts: 1298
Joined: 8/16/2005
Status: offline

take it to a place to get it serviced.

_____________________________

00 Jetta VR6 GLS 12V 2.8L
Magnaflow Exhaust
Custom Cold Air Intake
Eurosport Underdrive Pulley
GIAC Chip
Diamond Mesh Front Grill
Smoked Euro Tail Lights
18" ADR Rims
www.myspace.com/volkswagenforums
http://air2water.2ksite.com

(in reply to DonM77)

Post #: 2

RE: Ac issues on a 99 beetle - 5/7/2008 2:43:33 PM

mausolfh

Posts: 34
Joined: 7/7/2007
Status: offline

The AC system does have a pressure switch that will not allow the compressor to come on if the charge is low. You can check the compressor by removing the connector at the switch and jump terminals 1 and 2, that will bypass the switch. If you added some R134a to the system make sure it was added to the low side(marked by a L on the cap). The pressure should be around 35 to 45 psi if the system is good. This is checked with the system on and the fan on high. There are more fuses on the left side of the instrument panel under a plastic cover. Open the drivers side door and you will see and have access to it. The best way to test the system is with a manifold guage set to find out what the pressure is on both the high and low sides. Start with the simple and check all the fuses, both on the battery and on the inside. Then remove the connector on the compressor and clean it as well as the one on the pressure switch. If the fan works and the compressor clutch engages and still no cool air the problem my be in the rest of the system such as the receiver-dryer or possibly an overcharge.

(in reply to DonM77)

Post #: 3

RE: Ac issues on a 99 beetle - 5/7/2008 3:55:21 PM

blue99bug

Posts: 29
Joined: 5/1/2008
Status: offline

quote:

ORIGINAL: bagel

take it to a place to get it serviced. Earl couldn't have said it better!!!!
If you don't know , take it somewhere!!!
Earl

(in reply to bagel)

Post #: 4

RE: Ac issues on a 99 beetle - 5/7/2008 5:38:01 PM

DonM77

Posts: 4
Joined: 4/26/2008
Status: offline

quote:

ORIGINAL: mausolfh

The AC system does have a pressure switch that will not allow the compressor to come on if the charge is low. You can check the compressor by removing the connector at the switch and jump terminals 1 and 2, that will bypass the switch. If you added some R134a to the system make sure it was added to the low side(marked by a L on the cap). The pressure should be around 35 to 45 psi if the system is good. This is checked with the system on and the fan on high. There are more fuses on the left side of the instrument panel under a plastic cover. Open the drivers side door and you will see and have access to it. The best way to test the system is with a manifold guage set to find out what the pressure is on both the high and low sides. Start with the simple and check all the fuses, both on the battery and on the inside. Then remove the connector on the compressor and clean it as well as the one on the pressure switch. If the fan works and the compressor clutch engages and still no cool air the problem my be in the rest of the system such as the receiver-dryer or possibly an overcharge.

I'm aware of the fuse panel on the side of the dash, but I wasn't aware of any fuses that would be related to the issues I am having.

Thanks

(in reply to mausolfh)

Post #: 5